2021 CHRYSLER Pacifica

While driving down the highway at 70 miles per hour ater driving 2.5 hours our 2021 Pacifica hybrid minivan flashed a warning on the vehicles display saying approximately "Warning Engine Shutting Down". The engine immediately shut down in the middle of the highway and we were forced to coast off the highway to the shoulder. The engine warning light came on. We turned the car off for a few minutes and proceeded to start the engine. The engine warning light was still on, but the other message was gone. We attempted to drive towards our destination and approximately 30 minutes later the same thing happened again. We tried one more time since we were several hours from home and within 30 minutes the vehicle had the same issue. At that point we decided to try to get home. We drove the vehicle 15-20 mins at a time and then exited the highway over and over giving the vehicle time turned off. After returning home with no additional events the engine warning light went off the next warning. This was on a Sunday so we were unable to get it to a dealer. The next day we dropped off the vehicle at Nappletom Chrysler dealership. The called us the next day and told us they could not cause the event to happen again. They could see a set of error codes showing the problem occurred, but told us there was nothing they could do and it was up to us to cause the problem and then return the vehicle. Now I have a minivan with 70k miles on it that my wife primarily uses my with to get my daughter from place to place and I have no idea when this vehicle will shut the engine down at any time potentially causing a dangerous accident. I believe Chrysler has the responsibility to determine what the issue is. Researching on the internet show this is a common problem for my vehicle and typically requires a new transmission or and engine wiring short.

More often than not, the steering wheel column gets stuck at 10-11 o’clock positions and 1-2 o’clock positions. So it typically happens when making slight bends on my local roads and highways. This requires a hard jolt on the steering wheel to get it un-stuck. This is extremely unsafe to do at high rates of speed and/or with traffic on either side of me and it feels only a matter of time before it results in an accident. When I brought the car into the dealer for a different repair, they noted in their follow-up inspection a, “rep clunk from steering gear the wheel both ways” and quoted me $4800 for repair. I’m assuming that’s to replace the entire steering column, which is pretty outrageous considering the part is less than $900 OEM and would be about 2-3 hours of labor. I purchased the car 6 months ago as a certified pre-owned car from a dealership and the CarFax report came back completely clear, recall repairs weren’t even mentioned on it. I’ve seen some discussions on online forums describing a similar issue.

High pressure fuel leak with large fan spray pattern in fuel line part number 68492134AA where it sits and rubs against a sharp corner of another component, (appears to be ignition coil) above the rear passenger side of the engine. Searched online and found another owner had posted an image of the exact same leak! https://www.reddit.com/r/ChryslerPacifica/comments/1amcdp9/2021_pacifica_hybrid_fuel_leak/Their photo and mine are identical and in comments on their thread, Two other owners that responded to that thread also said they've also had exactly the same leak. The cause appears to be how this line is routed by the factory. it is resting against the coil and not secured in a way to prevent chafing. Result is extremely dangerous with fuel spraying down towards the exhaust. The part is available for inspection. Safety of my family was put at risk by fuel spraying towards hot exhaust while my wife was driving. She was unaware of problem until fuel smell just prior to arriving at home. Problem is easily reproduced. I spoke with Olympia Chrysler Jeep and the service advisor Corey, said he had seen this issue before as well. He also said because car is not under warranty and I don't have roadside assistance, towing would be at my expense. I have ordered replacement part and will install and secure it to prevent chafing. I will keep part to be availalbe for examination. There were no warning lamps, messages or other symptoms prior to the fuel smell.

2nd Row Seat fails to latch and lock in position. The seat reclines back and forth without being able to be latched in place. My [XXX] and [XXX] 's safety is greatly impacted by this, as the seat is unable to be properly secured in the event of a crash. I have had the other 2nd row seat repaired nearly 2 months ago at a Chrysler dealership, but am dealing with the same problem on the other 2nd row seat. When I took the vehicle to the dealership 2 months ago, the 2nd row seat that has now failed to latch was not experiencing those problems. There were no warning lamps or symptoms of this failure to occur other than knowing that the other 2nd row seat had experienced the same failure 2 months prior to this. A poor design in the seat reclining mechanism in the 2nd row seats of the Chrysler Pacifica by Chrysler appears to be the problem. Numerous other posts about this same issue exist on the [XXX] webpage, as well as by doing a google search on the failure INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)